Unit of Competency Mapping – Information for Teachers/Assessors – Information for Learners

PMAOPS290B Mapping and Delivery Guide
Operate a biotreater

Version 1.0
Issue Date: April 2024


Qualification -
Unit of Competency PMAOPS290B - Operate a biotreater
Description This unit covers the operation of a biotreater which is typically used for the reduction of BOD in an aqueous waste stream.
Employability Skills This unit contains employability skills.
Learning Outcomes and Application In a typical scenario, a plant produces an aqueous waste stream which has a high BOD/is contaminated with organic material. This waste stream is treated using a biotreater to produce a clean, low BOD effluent which is acceptable for discharge either to the sewer (as trade waste) or to a receiving waterway where it is within the environmental regulations/ license conditions. This unit includes the operation of all associated pumps, dosing pumps, agitation, aeration and similar equipment which is integral to the operation of the biotreater. The unit applies to any waste treatment facility using microorganisms to clean an aqueous stream. It includes biotreaters which use aerobic, anaerobic and/or facultative microorganismsThis unit does not apply to other waste treatment equipment (such as filtration or chemical dosing) which would be covered by the relevant OPS unit. The significant factor with this unit is not that it is treating waste, but that it is using microorganisms to perform the treatment at ambient temperatures. For temperature controlled microorganism based processes see PMAOPS390B Operate a biochemical processThe plant technician would:identify and rectify operational problemspredict the potential impact of feed changesfacilitate feed changesThis unit does not require the operation of a control panel - see relevant unit.
Duration and Setting X weeks, nominally xx hours, delivered in a classroom/online/blended learning setting.
Prerequisites/co-requisites
Competency Field
Development and validation strategy and guide for assessors and learners Student Learning Resources Handouts
Activities
Slides
PPT
Assessment 1 Assessment 2 Assessment 3 Assessment 4
Elements of Competency Performance Criteria              
Element: Monitor and control the biotreater processes
  • Get information relevant to the operation of the biotreater
  • Identify changes in key variables
  • Keep feed as consistent as possible
  • Check performance of ancillaries such as agitation
  • Recognise and interpret trends in biotreater data/appearance
  • Recognise the signs of potential and actual problems
  • Identify the consequences to the biotreater processes of the identified changes, trends and problems
  • Take appropriate action to minimise the impact of potential and actual problems.
       
Element: Ramp performance up/down.
  • Anticipate significant changes in feed
  • Breed up/down biomass to prepare for change in feed by changing variables
  • Ramp changed feed at a rate suitable for the biotreater
  • Establish stable operation for new feed conditions.
       
Element: Maintain effectiveness of biotreater system.
  • Frequently and critically monitor biotreater system throughout shift
  • Use measured/indicated data and smell, sight, sound and feel as appropriate
  • Identify critical equipment and processes
  • Identify issues likely to impact on the whole plant performance and take appropriate action
  • Predict impact of a change in the biotreater system on other plant units/areas and communicate this to relevant people
  • Predict impact of a change in the processing plant on the biotreater and take appropriate action
  • Test trips and alarms as required in liaison with the panel operator.
       
Element: Manage impact of shutdowns on biotreater system.
  • Identify type of shutdown required/occurring
  • Identify impact of type of shutdown on biotreater
  • Liaise with appropriate people for shutdown
  • Arrange to maintain adequate feed to biotreater for a short plant shutdown
  • Arrange to preserve adequate seed stock of micro-organisms for long plant shutdown or shutdown of biotreater
       
Element: Isolate and de-isolate biotreater.
  • Isolate biotreater or biotreater components
  • Make safe for required work
  • Check plant is ready to be returned to service
  • Prepare biotreater or plant component for return to service
  • Ramp biotreater back to normal operation..
       
Element: Control hazards.
  • Identify hazards in biotreater work area
  • Assess the risks arising from those hazards
  • Implement measures to control those risks in line with procedures and duty of care.
       


Evidence Required

List the assessment methods to be used and the context and resources required for assessment. Copy and paste the relevant sections from the evidence guide below and then re-write these in plain English.

The Evidence Guide provides advice on assessment and must be read in conjunction with the Performance Criteria, Required Skills and Knowledge, the Range Statement and the Assessment Guidelines for the Training Package.

Overview of assessment

Assessment of this unit should include demonstrated competence on actual plant and equipment in a work environment. The unit will be assessed in as holistic a manner as is practical and may be integrated with the assessment of other relevant units of competency. Assessment will occur over a range of situations which will include disruptions to normal, smooth operation.

Simulation may be required to allow for assessment of parts of this unit. Simulation should be based on the actual plant and will include walk-throughs of the relevant competency components. Simulations may also include the use of case studies/scenarios and role plays.

This unit of competency requires a significant body of knowledge which will be assessed through questioning and the use of what-if scenarios both on the plant (during demonstration of normal operations and walk throughs of abnormal operations) and off the plant.

Critical aspects for assessment and evidence required to demonstrate competency in this unit

Competence must be demonstrated in the ability to recognise and analyse potential situations requiring action and then in implementing appropriate corrective action. The emphasis should be on the ability to stay out of trouble rather than on recovery from a disaster.

Consistent performance should be demonstrated. In particular look to see that:

early warning signs of equipment/processes needing attention or with potential problems are recognised

the range of possible causes can be identified and analysed and the most likely cause determined

appropriate action is taken to ensure a timely return to full performance

obvious problems in related plant areas are recognised and an appropriate contribution made to their solution.

These aspects may be best assessed using a range of scenarios/case studies/what-ifs as the stimulus with a walk-through forming part of the response. These assessment activities should include a range of problems, including new, unusual and improbable situations which may have been generated from the past incident history of the plant, incidents on similar plants around the world, hazard analysis activities and similar sources.

Context of and specific resources for assessment

Assessment will require access to an operating plant over an extended period of time, or a suitable method of gathering evidence of operating ability over a range of situations. A bank of scenarios/case studies/what-ifs will be required as will a bank of questions which will be used to probe the reasoning behind the observable actions.

Method of assessment

In all plants it may be appropriate to assess this unit concurrently with relevant teamwork and communication units.

Guidance information for assessment

Assessment processes and techniques must be culturally appropriate and appropriate to the oracy, language and literacy capacity of the assessee and the work being performed.


Submission Requirements

List each assessment task's title, type (eg project, observation/demonstration, essay, assignment, checklist) and due date here

Assessment task 1: [title]      Due date:

(add new lines for each of the assessment tasks)


Assessment Tasks

Copy and paste from the following data to produce each assessment task. Write these in plain English and spell out how, when and where the task is to be carried out, under what conditions, and what resources are needed. Include guidelines about how well the candidate has to perform a task for it to be judged satisfactory.

This describes the essential skills and knowledge and their level, required for this unit.

Required skills

observation

interpretation

analysis.

Competence also includes the ability to isolate the causes of problems to an item of equipment within the biotreater system and distinguish between causes of problems/alarm/fault indications such as:

feed variations

instrument failure/wrong reading

electrical failure

mechanical failure

operational problem.

Required knowledge

Competence includes an understanding of the biotreater system and its integral equipment to the level needed to control the system and resolve problems, ie:

identify all items on a schematic of the biotreater system and describe the function of each

describe the nature/condition of materials entering and leaving each stage of the process, the changes which have occurred in that stage and why they have occurred

state the biochemical changes which are occurring in each stage and the methods of controlling them

describe methods of ramping up/down in response to feed changes and the advantages and disadvantages of each.

The Range Statement relates to the unit of competency as a whole. It allows for different work environments and situations that may affect performance. Bold italicized wording, if used in the Performance Criteria, is detailed below. Add any essential operating conditions that may be present with training and assessment depending on the work situation, needs if the candidate, accessibility of the item, and local industry and regional contexts.

Codes of practice/ standards

Where reference is made to industry codes of practice, and/or Australian/international standards, the latest version must be used.

Context

This unit of competency includes all such items of equipment and unit operations which form part of the biotreater system. For your plant this may include (select relevant items):

pumps (feed and dosing pumps)

utilities and services such as air

agitators

air/gas supply/removal

other equipment integral to the operation of the biotreater system.

Appropriate action

Appropriate action includes:

determining problems needing action

determining possible fault causes

rectifying problem using appropriate solution within area of responsibility

following through items initiated until final resolution has occurred

reporting problems outside area of responsibility to designated person.

Procedures

Procedures may be written, verbal, computer-based or in some other form. They include:

all work instructions

standard operating procedures

formulas/recipes

batch sheets

temporary instructions

any similar instructions provided for the smooth running of the plant.

For the purposes of this Training Package, 'procedures' also includes good operating practice as may be defined by industry codes of practice (eg Responsible Care) and government regulations.

Typical problems

Typical problems for your plant may include:

sudden changes in feed (rate, composition, concentration)

handling a plant shutdown without allowing the micro-organisms to die

control of degree of agitation

settling/removal/recycling of biosolids.

Key variables

Key variables include:

feed rate

feed composition

feed concentration

rapid changes in feed characteristic

Biomass variables

Biomass variables include:

nutrient dosing

aeration rate (if appropriate)

agitation rate

Health, safety and environment (HSE)

All operations to which this unit applies are subject to stringent health, safety and environment requirements, which may be imposed through State or Federal legislation, and these must not be compromised at any time. Where there is an apparent conflict between Performance Criteria and HSE requirements, the HSE requirements take precedence.

Copy and paste from the following performance criteria to create an observation checklist for each task. When you have finished writing your assessment tool every one of these must have been addressed, preferably several times in a variety of contexts. To ensure this occurs download the assessment matrix for the unit; enter each assessment task as a column header and place check marks against each performance criteria that task addresses.

Observation Checklist

Tasks to be observed according to workplace/college/TAFE policy and procedures, relevant legislation and Codes of Practice Yes No Comments/feedback
Get information relevant to the operation of the biotreater 
Identify changes in key variables 
Keep feed as consistent as possible 
Check performance of ancillaries such as agitation 
Recognise and interpret trends in biotreater data/appearance 
Recognise the signs of potential and actual problems 
Identify the consequences to the biotreater processes of the identified changes, trends and problems 
Take appropriate action to minimise the impact of potential and actual problems. 
Anticipate significant changes in feed 
Breed up/down biomass to prepare for change in feed by changing variables 
Ramp changed feed at a rate suitable for the biotreater 
Establish stable operation for new feed conditions. 
Frequently and critically monitor biotreater system throughout shift 
Use measured/indicated data and smell, sight, sound and feel as appropriate 
Identify critical equipment and processes 
Identify issues likely to impact on the whole plant performance and take appropriate action 
Predict impact of a change in the biotreater system on other plant units/areas and communicate this to relevant people 
Predict impact of a change in the processing plant on the biotreater and take appropriate action 
Test trips and alarms as required in liaison with the panel operator. 
Identify type of shutdown required/occurring 
Identify impact of type of shutdown on biotreater 
Liaise with appropriate people for shutdown 
Arrange to maintain adequate feed to biotreater for a short plant shutdown 
Arrange to preserve adequate seed stock of micro-organisms for long plant shutdown or shutdown of biotreater 
Isolate biotreater or biotreater components 
Make safe for required work 
Check plant is ready to be returned to service 
Prepare biotreater or plant component for return to service 
Ramp biotreater back to normal operation.. 
Identify hazards in biotreater work area 
Assess the risks arising from those hazards 
Implement measures to control those risks in line with procedures and duty of care. 

Forms

Assessment Cover Sheet

PMAOPS290B - Operate a biotreater
Assessment task 1: [title]

Student name:

Student ID:

I declare that the assessment tasks submitted for this unit are my own work.

Student signature:

Result: Competent Not yet competent

Feedback to student

 

 

 

 

 

 

 

 

Assessor name:

Signature:

Date:


Assessment Record Sheet

PMAOPS290B - Operate a biotreater

Student name:

Student ID:

Assessment task 1: [title] Result: Competent Not yet competent

(add lines for each task)

Feedback to student:

 

 

 

 

 

 

 

 

Overall assessment result: Competent Not yet competent

Assessor name:

Signature:

Date:

Student signature:

Date: